中國一拖：備戰秋收，做好這些功課能助你多收糧食

2020-09-10 09:19:23 來源：中國一拖 閱讀量：18028 評論

　　【農機網 明星企業】 2020年秋收帷幕即將拉開,東方紅玉米機的老鐵們，你們的“戰車”是否已經準備就緒？為了保障您的愛車馳騁原野，收獲秋天的一份甜蜜和喜悅，東方紅金色服務友情提示,下地作業前請注意以下事項：

　　1.油料備足，軟水加滿
 
 
收割機要想跑的“得勁”，需要6種“油”+1種“水”！
 
 
機油：磨合50個小時免費首保，逾期不候。
 
 
液壓油：工作50個小時更換，保持油質清潔。
 
 
齒輪油：參照各齒輪箱體上的加油限位孔要求適量添加。

剎車油：準備2瓶剎車油備用，剎車油箱加足油。

柴油：下地收割“沖鋒”前，請務必把柴油箱加滿。
 
　　濾芯：換油的同時，與機油和液壓油相關的濾芯全部要換掉，柴油濾芯也需要在每工作200個小時后更換，切記且牢記!忘記等于“浪費油”。
 
　　潤滑脂：即“黃油”，原則上要“勤打+少打”，檢查所有軸承注油情況，按照注油要求定期加注，確保所有軸承不能缺油，同時不過量注油，以防崩裂密封圈。
 
　　特別提示：變速箱游輪處、無級變速輪軸座處、后橋轉向節等三處關鍵部位請確保加注潤滑脂。
 
水質要求：水箱里一定要加軟水，推薦加注純凈水或不含可溶性鈣、鎂化合物的凈化水。
 
加水提示：放水時一定要先打開水箱蓋，再把水箱和發動機的放水開關打開，將水放凈。

　　2.皮帶全張緊，鏈條不松弛
  
鏈條和皮帶分布及型號

 
注意事項
 
　　檢查主離合皮帶與托板之間的間隙是否保持在5-7mm的間隙，并在分離狀態時皮帶不聯動。
 
 
　　皮帶張緊遵從適中偏緊原則，保持有足夠的摩擦力，不松弛；鏈條張緊時將張緊輪調整到底，被壓制鏈條撓度小于2mm。
 
鏈條一定要勤保養，作業期間保持鏈條處于潤滑狀態，每日加注一定量的潤滑油脂；
 
皮帶不能沾染任何潤滑油脂，以防皮帶摩擦力減小，造成打滑聯動而燒毀。
 
　　3.升運鏈耙，平衡張緊

 
注意事項：
 
兩側同步張緊。調整螺栓在升運器的頂部，兩側螺栓調整幅度一致，保證張緊度協調。
 
調整程度：整機運轉時，鏈耙沒有明顯的摩擦和刮碰聲音。
 
　　4.剝皮裝置，適時調整

 
注意事項：
 
檢查每組剝皮棍的調整彈簧壓縮后長度是否為65-75mm。
 
　　根據玉米的剝凈率，調整壓送器的高低，向上調整手柄是降低壓送器的高度，反之亦然；兩側手柄的調整幅度保持一致，不能有偏差。
 
　　5.摘穗割臺，重點調試

注意事項：
 
調緊左右輸送槽的輸送鏈的張緊度，撓度不大于20mm。
 
打開割臺上部護罩，檢查撥禾鏈裝配是否處于交錯狀態，張緊彈簧的壓縮量為25mm。

 
檢查摘穗輥的間隙，導入錐中心距是否保持為100-105mm。
 
　　清草刀與摘穗輥高棱邊間隙小于3mm，有無剮蹭現象。
 
　　檢查導入板是否對準導錐錐端，距錐頂間隙是否保持5-10mm。
 
　　6.檢測氣壓，氣罐放水
注意事項：
 
 
請記得儲氣罐每天需要放水！
  
 
行車前務必檢查制動氣壓，氣壓值達到0.6Mpa后方可行車。

 

上一篇： 山西農機發展中心聯手雷沃重工舉辦“關愛留守兒童計劃”捐贈活動

下一篇：大疆農業：熱帶作物飛防，大有可為！

我要評論
文明上網，理性發言。（您還可以輸入200個字符)

所有評論僅代表網友意見，與本站立場無關。

產品推薦 更多

[{"ID":"3173339","Picture":"mt0003/1ef287ee8bdc4a029c334c9b99d38257cae019ac53dcbb1af04edc614dcfc44b6288c22d6b813cee.jpg","PictureDomain":"img70","Name":"YZH-K防爆電子振動開關","Type":"HZD-B-III（HZD-B-3）","Descrip":"HZD-B-III 防爆電子振動開關(生產廠家）主要用于對轉速600～60000轉/分的旋轉機械振動烈度、振動位移進行長期監測。與磁電式振動速度傳感器配套，可以監測旋轉機械的垂直、水平方向的振動，振動值大小由儀器前端的LED數碼管顯示；同時具有標準的模擬電流輸出，可與DCS、PLC等系統配接；當振動值超*，本儀器設有報警、危險開關量輸出，可外接聲光報警器以提示現場操作人員采取防范措施，","CompanyName":"安徽春輝儀表線纜集團有限公司","CompanyID":"141039","MarketPrice":"0","PsOrder":"0","PgID":"110","MaxOrder":"0","CityID":"119","City":"滁州市","Address":"滁州市","PropertysValue":"","HitNumber":"52","FrontShow":"0","IsCharges":"1","Year":"1","StarNum":"1","UpdateAndClientSort":"51673776","StandUrl":"/st141039","UpdateTime":"2025/3/12 18:56:07","TodayIsUpdate":"1","AttType":"0","AttState":"3","AttAddType":"3","IsSeoCreate":"0","IsOnlinePay":"0","MinPrice":"0.00","MaxPrice":"0.00","ClassID":"21002","productonlinetime":"1900/1/1 0:00:00","OnLineDate":"1900/1/1 0:00:00","DownLineDate":"1900/1/1 0:00:00","BrandPicDomin":"","BrandPicName":"","BrandProperty":"","PBrandID":"0","IsHadVideo":"0","VideoTime":"0","ShowPrice":"0.00","IndustrySort":"1020000","HasPicSort":"103173339","UserID":"154029","PriceType":"0","PictureID":"1961675","CompanyTypeID":"5","Tag":"","LinkMan":"張經理","TelPhone":"18205507022","ClassName":"其它","ComProduct":"儀器儀表","BrandNameCH":"","IsShow":"1","MarketPrice2":"0","RetailPrice":"0","ComHitnumber":"6623","MarketUpdateTime":"","CreateTime":"2024/10/29 0:45:09","Flag":"1","PackageName":"營銷寶會員","ClientSort":"0","CsName":"","Reprint":"2","FeedBackMsg":"","EnUrl":"","MobilePhone":"18205507022"},{"ID":"3044446","Picture":"00450ea57bc9bc7dca14a12b2faba4262777492a10b07479a17b3ee7f33ce6976fc9554b8826048e.jpg","PictureDomain":"img73","Name":"國產熱式氣體流量計生產","Type":"MFM-50","Descrip":"氣體流量計選型專門用于氣體流量的高精度測量。該系列流量計采用業內優良的流量傳感芯片，結合航空鋁材拋光氣體流道設計以及公司核心的標定和補償算法","CompanyName":"青島芯笙微納電子科技有限公司","CompanyID":"129194","MarketPrice":"0","PsOrder":"0","PgID":"110","MaxOrder":"0","CityID":"148","City":"青島市","Address":"青島市","PropertysValue":"","HitNumber":"76","FrontShow":"0","IsCharges":"1","Year":"1","StarNum":"1","UpdateAndClientSort":"51673776","StandUrl":"/st129194","UpdateTime":"2025/3/12 18:56:00","TodayIsUpdate":"1","AttType":"0","AttState":"3","AttAddType":"3","IsSeoCreate":"0","IsOnlinePay":"0","MinPrice":"0.00","MaxPrice":"0.00","ClassID":"21002","productonlinetime":"1900/1/1 0:00:00","OnLineDate":"1900/1/1 0:00:00","DownLineDate":"1900/1/1 0:00:00","BrandPicDomin":"","BrandPicName":"","BrandProperty":"","PBrandID":"0","IsHadVideo":"0","VideoTime":"0","ShowPrice":"0.00","IndustrySort":"1020000","HasPicSort":"103044446","UserID":"142183","PriceType":"0","PictureID":"1678422","CompanyTypeID":"5","Tag":"","LinkMan":"芯笙微納","TelPhone":"","ClassName":"其它","ComProduct":"質量流量控制器，質量流量計","BrandNameCH":"","IsShow":"1","MarketPrice2":"0","RetailPrice":"0","ComHitnumber":"32163","MarketUpdateTime":"","CreateTime":"2024/5/24 1:31:42","Flag":"1","PackageName":"營銷寶會員","ClientSort":"0","CsName":"","Reprint":"2","FeedBackMsg":"","EnUrl":"","MobilePhone":"4000066550"},{"ID":"3068620","Picture":"74a34d6b99a3c732c8a3b6bb817fa77d907cbb9288b8e5b5a39be792670bea21714c8f852afe5e83.jpg","PictureDomain":"img59","Name":"國產稱重顯示控制器價格","Type":"LC200-P","Descrip":"LC200系列稱重顯示控制器是專門為皮帶秤計量應用而開發的中高檔儀表。采用了32位ARM單片機、多任務實時操作系統、現場總線通訊等技術，結合全圖形化中文操作界面。","CompanyName":"四川浩馳儀器儀表有限公司","CompanyID":"138827","MarketPrice":"0","PsOrder":"0","PgID":"110","MaxOrder":"0","CityID":"252","City":"德陽市","Address":"德陽市","PropertysValue":"","HitNumber":"122","FrontShow":"0","IsCharges":"1","Year":"1","StarNum":"1","UpdateAndClientSort":"51673775","StandUrl":"/st138827","UpdateTime":"2025/3/12 18:55:41","TodayIsUpdate":"1","AttType":"0","AttState":"3","AttAddType":"3","IsSeoCreate":"0","IsOnlinePay":"0","MinPrice":"0.00","MaxPrice":"0.00","ClassID":"21002","productonlinetime":"1900/1/1 0:00:00","OnLineDate":"1900/1/1 0:00:00","DownLineDate":"1900/1/1 0:00:00","BrandPicDomin":"","BrandPicName":"","BrandProperty":"","PBrandID":"0","IsHadVideo":"0","VideoTime":"0","ShowPrice":"0.00","IndustrySort":"1020000","HasPicSort":"103068620","UserID":"151817","PriceType":"0","PictureID":"1890193","CompanyTypeID":"5","Tag":"","LinkMan":"黃經理","TelPhone":"","ClassName":"其它","ComProduct":"恒溫設備，便攜式紅外測溫儀、氣體檢測儀器，化工機械，無損檢測儀器，流量儀表，數顯儀表，傳感器，干燥箱，電子儀器儀表","BrandNameCH":"","IsShow":"1","MarketPrice2":"0","RetailPrice":"0","ComHitnumber":"11364","MarketUpdateTime":"","CreateTime":"2024/6/26 9:15:59","Flag":"1","PackageName":"營銷寶會員","ClientSort":"0","CsName":"","Reprint":"2","FeedBackMsg":"","EnUrl":"","MobilePhone":"18980874109"},{"ID":"2724315","Picture":"00450ea57bc9bc7d1e06a3790378fa897c8e3761ede7614ed8b81b5108e66d8e229d37c38159bda5.jpg","PictureDomain":"img73","Name":"普析L6312-53氘燈價格","Type":"","Descrip":"普析通用T6分光光度計氘燈濱松L6312-53氘燈具有高穩定性、高輸出、工作壽命長等特點。","CompanyName":"上海惠分科學分析儀器有限公司","CompanyID":"129283","MarketPrice":"0","PsOrder":"0","PgID":"110","MaxOrder":"0","CityID":"392","City":"國外","Address":"國外","PropertysValue":"","HitNumber":"128","FrontShow":"0","IsCharges":"1","Year":"1","StarNum":"1","UpdateAndClientSort":"51673775","StandUrl":"/st129283","UpdateTime":"2025/3/12 18:55:04","TodayIsUpdate":"1","AttType":"0","AttState":"3","AttAddType":"3","IsSeoCreate":"0","IsOnlinePay":"0","MinPrice":"0.00","MaxPrice":"0.00","ClassID":"21002","productonlinetime":"1900/1/1 0:00:00","OnLineDate":"1900/1/1 0:00:00","DownLineDate":"1900/1/1 0:00:00","BrandPicDomin":"","BrandPicName":"","BrandProperty":"","PBrandID":"0","IsHadVideo":"0","VideoTime":"0","ShowPrice":"0.00","IndustrySort":"1020000","HasPicSort":"102724315","UserID":"142272","PriceType":"0","PictureID":"1684827","CompanyTypeID":"5","Tag":"","LinkMan":"胡紅梅","TelPhone":"13651667376","ClassName":"其它","ComProduct":"氣相色譜儀，自動進樣器，氣體發生器，純水機等，","BrandNameCH":"","IsShow":"1","MarketPrice2":"0","RetailPrice":"0","ComHitnumber":"32443","MarketUpdateTime":"","CreateTime":"2015/10/1 0:01:04","Flag":"1","PackageName":"營銷寶會員","ClientSort":"0","CsName":"","Reprint":"2","FeedBackMsg":"","EnUrl":"","MobilePhone":"13651667376"},{"ID":"2743392","Picture":"66dabcda8ca7909d8fb1410a3f90c1da866a3d1f31032e405c6a57fefda96dba0e436bc10ed0ac07.jpg","PictureDomain":"img63","Name":"國產滾筒刮板干燥機生產","Type":"HG","Descrip":"滾筒刮板干燥機是一種內加熱傳導型轉動連續干燥設備。旋轉的滾筒通過其下部料槽，粘附著一厚度的料膜，熱量通過管道輸送至滾筒內壁，傳導到滾筒外壁，再傳導給料膜，使料膜中的濕得到蒸發、脫濕、使含濕分的物料得到干燥。干燥好的物料被裝置在滾筒表面的刮刀鏟離滾筒，到置于刮刀下方的螺旋輸送器，通過螺旋輸送器將干物料集中、包裝。","CompanyName":"常州市瑞庭干燥工程有限公司","CompanyID":"129501","MarketPrice":"0","PsOrder":"0","PgID":"110","MaxOrder":"0","CityID":"89","City":"常州市","Address":"常州市","PropertysValue":"","HitNumber":"144","FrontShow":"0","IsCharges":"1","Year":"1","StarNum":"1","UpdateAndClientSort":"51673774","StandUrl":"/st129501","UpdateTime":"2025/3/12 18:54:29","TodayIsUpdate":"1","AttType":"0","AttState":"3","AttAddType":"3","IsSeoCreate":"0","IsOnlinePay":"0","MinPrice":"0.00","MaxPrice":"0.00","ClassID":"21002","productonlinetime":"1900/1/1 0:00:00","OnLineDate":"1900/1/1 0:00:00","DownLineDate":"1900/1/1 0:00:00","BrandPicDomin":"","BrandPicName":"","BrandProperty":"","PBrandID":"0","IsHadVideo":"0","VideoTime":"0","ShowPrice":"0.00","IndustrySort":"1020000","HasPicSort":"102743392","UserID":"142490","PriceType":"0","PictureID":"1702851","CompanyTypeID":"5","Tag":"","LinkMan":"吳經理","TelPhone":"13921042531","ClassName":"其它","ComProduct":"干燥設備，制粒設備，混合設備，篩選設備","BrandNameCH":"","IsShow":"1","MarketPrice2":"0","RetailPrice":"0","ComHitnumber":"28756","MarketUpdateTime":"","CreateTime":"2023/4/22 16:03:03","Flag":"1","PackageName":"營銷寶會員","ClientSort":"0","CsName":"","Reprint":"2","FeedBackMsg":"","EnUrl":"","MobilePhone":"15706156656"},{"ID":"3221315","Picture":"mt0001/f05c972a1daef939171c733e8bcaf1d0c56fafa023b6918e1127458a9524cad15eeab46916311c1d.jpg","PictureDomain":"img41","Name":"銷售U型真空計","Type":"","Descrip":"U型真空計,U型壓力真空計,真空表（以下簡稱真空計）是測量粗真空壓力的理想儀表，它結構小巧美觀、重量輕、安裝操作方便，其特點是精度高、響應快、測幅度廣、穩定可靠、零部件采用不銹鋼制品，有較高的耐腐蝕性，這些都是其它壓力真空計不可比擬的。","CompanyName":"上海家君真空儀表制造有限公司","CompanyID":"141809","MarketPrice":"0","PsOrder":"0","PgID":"110","MaxOrder":"0","CityID":"3","City":"上海市","Address":"上海市","PropertysValue":"","HitNumber":"92","FrontShow":"0","IsCharges":"1","Year":"1","StarNum":"1","UpdateAndClientSort":"51673772","StandUrl":"/st141809","UpdateTime":"2025/3/12 18:52:11","TodayIsUpdate":"1","AttType":"0","AttState":"3","AttAddType":"3","IsSeoCreate":"0","IsOnlinePay":"0","MinPrice":"0.00","MaxPrice":"0.00","ClassID":"21002","productonlinetime":"1900/1/1 0:00:00","OnLineDate":"1900/1/1 0:00:00","DownLineDate":"1900/1/1 0:00:00","BrandPicDomin":"","BrandPicName":"","BrandProperty":"","PBrandID":"0","IsHadVideo":"0","VideoTime":"0","ShowPrice":"0.00","IndustrySort":"1020000","HasPicSort":"103221315","UserID":"154810","PriceType":"0","PictureID":"2000912","CompanyTypeID":"5","Tag":"","LinkMan":"浦克恒","TelPhone":"13817381801","ClassName":"其它","ComProduct":"ZDJ-2型熱偶真空計、組合式麥氏真空計，高精度直立式麥氏真空計、用于檢測粗真空的U型閉口水銀真空計和杯型壓力真空計","BrandNameCH":"","IsShow":"1","MarketPrice2":"0","RetailPrice":"0","ComHitnumber":"3704","MarketUpdateTime":"","CreateTime":"2024/12/21 13:38:06","Flag":"1","PackageName":"營銷寶會員","ClientSort":"0","CsName":"","Reprint":"2","FeedBackMsg":"","EnUrl":"","MobilePhone":"13817381801"}]